Fe-Ce/GAC催化臭氧降解高浓度腐殖酸废水

采用浸渍焙烧法制备了Fe-Ce/GAC催化剂,并用于催化臭氧降解模拟高浓度腐殖酸废水.以废水COD、腐殖酸浓度为考察指标,研究了Fe-Ce/GAC催化剂的前驱体无机铁盐种类、焙烧温度、铁盐浓度、助剂稀土元素种类及浓度、分散剂硝酸钾浓度等不同制备条件对催化臭氧降解腐殖酸的效果.试验表明,在腐殖酸浓度为3.00 g·L~(-1)、pH值约8.0、温度为25℃、臭氧投量为1.24 g·h~(-1),反应40 min后COD、腐殖酸去除率仅为17.1%、43.0%;添加以2.0%硝酸铁、1.5%硝酸铈、1.0%硝酸钾溶液浸渍,经350℃焙烧3 h后制备的Fe-Ce/GAC催化剂,可使COD、腐殖酸去除率分别提高40.3%、31.8%.且Fe-Ce/GAC催化剂具有较好的稳定性,重复使用5次后,COD、腐殖酸去除率仅小幅降低了4.2%、9.1%.SEM图象显示活性炭经改性后,比表面积明显增大,有利于活性物质的负载;EDS分析表明催化剂负载了大量的Fe、Ce等金属物质;XRD图谱显示催化剂含有Fe_2O_3、CeO_2等多种活性物质.Fe-Ce/GAC催化臭氧的机理可解释为:活性成分氧化铁在催化过程中生成的羟基氧化铁会促进羟基自由基的生成,而铈元素在催化过程中不仅会提高催化剂的活性,而且生成的化学吸附氧可促进对有机物的吸附及氧化.     

Investigation of a filter explosion

At about 10 o'clock on a summer morning in 1987, an industrial filter used to purify an electrolytic plating solution exploded at a printed wiring board manufacturing plant. An investigation team used the failure modes and effects analysis technique to identify potential failures that could have caused the explosion and to reconstruct the most probable sequence of events that led to the accident. This paper describes the investigation and its results.     

Minimization of the formation of disinfection by-products

The drinking water industry is required to minimize DBPs levels while ensuring adequate disinfection. In this study, efficient and appropriate treatment scheme for the reduction of disinfection by-product (DBPs) formation in drinking water containing natural organic matter has been established. This was carried out by the investigation of different treatment schemes consisting of enhanced coagulation, sedimentation, disinfection by using chlorine dioxide/ozone, filtration by sand filter, or granular activated carbon (GAC). Bench scale treatment schemes were applied on actual samples from different selected sites to identify the best conditions for the treatment of water. Samples were collected from effluent of each step in the treatment train in order to analyze pH, UV absorbance at 254 nm (UVA₂₅₄), specific UV absorbance at 254 nm (SUVA₂₅₄), dissolved organic carbon (DOC), haloacetic acids (HAAs) and trihalomethanes (THMs). The obtained results indicated that using pre-ozonation/enhanced coagulation/activated carbon filtration treatment train appears to be the most effective method for reducing DBPs precursors in drinking water treatment.     

城市再生水生产工艺中典型紫外防晒剂的去除

随着紫外防晒剂在个人护理用品中的大量使用,其环境及健康风险效应开始得到人们的关注.采用固相萃取-气相色谱-质谱联用(SPE-GC-MS)技术对天津某再生水厂不同处理单元中4种典型紫外防晒剂4-甲氧基肉桂酸-2-乙基己基酯(ethylhexylmethoxycinnamate,EHMC),羟苯甲酮(benzophenone-3,BP-3),3-(4-甲苯基亚甲基)-d-1-樟脑(4-methylbenzylidene,4-MBC),2-氰基-3,3-二苯基丙酸-(2-乙基)己基酸(octocylene,OC)的分布及去除情况进行了检测.结果表明,污水处理厂二级出水中4种目标化合物的浓度范围在34ng·L-1￣2128ng·L-1之间;4种物质在夏秋季(7月和9月)的浓度普遍高于冬季(2月).污水处理厂二级出水中的这4种紫外防晒剂在经过混凝-絮凝处理、连续膜过滤和臭氧氧化处理后出水中的浓度呈下降趋势,总去除率为28.3%￣43.1%,其中臭氧氧化阶段对目标物的去除率最大(16%￣29%),而连续膜过滤阶段去除率最小(3.6%￣8.5%),混凝-絮凝阶段去除率介于2者之间(8%￣21%).由此可见,紫外防晒剂在再生水处理过程中并未得到完全去除,因此再生水的使用需经周密规划,以免对人体健康和生态环境造成威胁.     

四种净水工艺对水源水微量有机物去除的研究

以UV254和CODMn代表饮用水源水中有机物替代指标.对常规处理、生物陶粒预处理、生物滤池、生物活性炭(BAC)、颗粒活性炭(GAC)、纳滤和光催化氧化进行组合,形成不同的处理流程,研究各流程对UV254和CODMn的去除效果.结果表明,各工艺流程都有一定的处理效率,其中以生物滤池和纳滤为主的组合流程处理效果最佳.此流程对UV254的去除率接近100%,CODMn的去除率达到78.6%,大大提高了饮用水的安全性.     

GAC-O3/H2O2体系去除准好氧矿化垃圾床渗滤液尾水中难降解有机物的研究

为了降低准好氧矿化垃圾床渗滤液尾水中有机物浓度和提高体系可生化性,构建了GAC(粒状活性炭)-O_3/H_2O_2体系催化降解矿化垃圾床渗滤液尾水中有机物.同时,考察了体系O_3、GAC和H_2O_2投加量、初始pH值对GAC-O_3/H_2O_2体系处理渗滤液尾水的影响,并使用分子量分布、紫外-可见光谱和三维荧光光谱解析了难降解有机物在GAC-O_3/H_2O_2体系的转化机制.结果表明:在GAC投加量为10 g·L-1,O_3投加量为32.16 mg·min-1,H_2O_2投加量为3 m L·L-1,初始pH值为5的条件下,反应20 min后,其渗滤液尾水的COD和UV245分别从700.08 mg·L~(-1)和0.488下降到393.85 mg·L~(-1)和0.244,COD和UV254的去除率分别为43.80%和50.00%.经GAC-O_3/H_2O_2体系处理后,得益于含芳香环有机物的有效降解,渗滤液尾水中大分子有机物(大于50 k Da)明显减少,分子量小于1 k Da的有机物比例增多.与此同时,紫外区类富里酸荧光区及可见光区类富里酸荧光区峰值也大幅降低,其去除率分别为70.20%和58.69%,B/C从0.04增加到0.35,这也使得废水可生化性大幅提高.     

GAC-石英砂滤池处理高氨氮原水的生产研究

以广州市珠江流溪河下游为水源,采用GAC-石英砂滤池处理沉淀池出水,研究了该工艺对枯水期高氨氮原水的去除规律及其影响因素。结果表明:GAC-石英砂滤池滤与普通砂滤池相比氨氮的去除显著提高,滤后水氨氮平均值为2.08mg/L,去除量约为1.0mg/L,去除率为33.8%。研究显示氨氮处理效果受余氯的灭菌作用、溶解氧不足、原水水质下降、pH值不足、活性炭滤料吸附性能下降、空床接触时间短、反冲洗周期与强度的影响。建议降低前投氯而加强后投氯量,同时使用无氯水进行反冲洗;保持滤后水溶解氧在2～4mg/L且pH值7.5;延长反冲洗周期至36h;适当降低运行负荷可提高GAC-石英砂滤池对氨氮的去除效果。     

疾病预防控制中心废水处理技术工程实例

疾病预防控制机构废水具有重金属种类繁多、含病原体数量大、间断性排放等特点,通过运用混凝沉淀＋曝气生物滤池（BIOFOR）＋ClO2消毒工艺对其废水进行处理,处理后废水达到《医疗机构水污染物排放标准（》GB18466-2005）排放标准。     

Particle properties in granular activated carbon filter during drinking water treatment

The elemental composition and bacteria attached in particles were investigated during granular activated carbon (GAC) filtration.The experimental results showed that trapped influent particles could form new,larger particles on GAC surface.The sloughing of individuals off GAC surface caused an increase in effluent particles in the size range from 5 to 25 μm.The selectivity for element removal in GAC filters caused an increasing proportion of metallic elements in the effluent particles.The distribution of molar ratio indicated a complicated composition for large particles,involving organic and inorganic substances.The organic proportion accounted for 40% of total carbon attached to the particles.Compared with dissolved carbon,there was potential for the formation of trihalomethanes by organic carbon attached to particles,especially for those with size larger than 10 μm.The pure carbon energy spectrum was found only in the GAC effluent and the size distribution of carbon fines was mainly above 10 μm.The larger carbon fines provided more space for bacterial colonization and stronger protection for attached bacteria against disinfection.The residual attached bacteria after chorine disinfection was increased to 10 2-10 3 CFU/mL within 24 hours at 25°C.     

采用TSF技术改善电力变压器运行的安全性

分析了无功功率和高次谐波对电力变压器的危害,介绍了晶闸管投切滤波器(TSF)装置的特点、结构原理．提出了TSF装置在工厂实际应用中的主电路结构,操作及控制方案。实践证明,TSF晶闸管投切滤波器装置起到了高效节能、优化电能质量的作用,保证了电网的安全运行。